⌛Y3 Roof Diagnostic System (for all BMW convertible & roadster)

B21 · Post by **B21** » Tue Dec 27, 2022 12:38 pm

Smoking..

RobbiZ4 · Post by **RobbiZ4** » Tue Dec 27, 2022 1:19 pm

B21 wrote: ↑Tue Dec 27, 2022 12:38 pm Smoking..

Indeed, that was smoking hot and smelling awfull, even after some days

B21 · Post by **B21** » Tue Dec 27, 2022 2:07 pm

RobbiZ4 wrote: ↑Tue Dec 27, 2022 1:19 pm
B21 wrote: ↑Tue Dec 27, 2022 12:38 pm Smoking..
Indeed, that was smoking hot and smelling awfull, even after some days

Burnt circuit boards never smell good…had an aircraft transponder ‘blow up’ inside its metal box…crew poohed themselves and did an emergency landing with the smell n smoke..when we opened up the box there was a very bad burn mark and a disrupted power IC…

RobbiZ4 · Post by **RobbiZ4** » Tue Dec 27, 2022 4:17 pm

In my case it was more current than expected when this elder, powerful motor of an E85 reached it's physical limitation.
All former tests led to about 10 amps without any damage of the circuit board.

RobbiZ4 · Post by **RobbiZ4** » Tue Jun 27, 2023 10:33 pm

RobbiZ4 wrote: ↑Fri May 21, 2021 11:42 pm As of today, I've completed the next concentrator box (BlueBox K2) for another couple of BMW convertibles:
F33 (4series)
F83 (4series M)
F91(M8)
G14(8series]

In these days I got the chance to take a roof EKG from a rather new BMW M8 convertible (F91).

: Bild1.jpg (136.11 KiB) Viewed 528 times

It had no faults, but I was able to take a reference chart of all roof and trunk functions.

This is, once again, a very impressive piece of technology, which will run into spooky faults in it's age of 10-15 years.

Even the hydraulic trunk lid lift is managed by the hydraulic pump of the roof!

24 different signals of sensors as well as actors got plottet into a single EKG.

Cyntraxx · Post by **Cyntraxx** » Sun Oct 08, 2023 2:15 pm

Is this available for someone like ME? I replaced my entire roof because they told me it was a bad microsensor and they couldn't just fix that!
Obviously, they didn't have a diagnostic tool like this!!
I was lucky enough to find a replacement roof on ebay for a few hundred dollars (even the right color)..
I replaced the Hydraulic pump myself (also with a used one).. after all this, occasionally I still get the red blinking light on the switch, an error message on the screen says the top is not locked, and my windows and trunk won't open - plus that very annoying loud error beep as I drive!!
Then suddenly, that all stops!
I'm afraid to put my top down since it was replaced last year!! I'm afraid it'll get stuck half way down!!
Please help me!!

RobbiZ4 · Post by **RobbiZ4** » Sun Oct 08, 2023 10:24 pm

Cyntraxx wrote: ↑Sun Oct 08, 2023 2:15 pm Is this available for someone like ME?

No. As initially written, we are talking about a self developed package of hardware tools, which can be combined in different setups to support each BMW convertible from Z8 up to i8 Roadster

This thread is not intended to discuss individual support cases. These should be placed under "E89 Problems"!

flybobbie · Post by **flybobbie** » Sun Oct 08, 2023 10:31 pm

People are happy to buy a 10-40k car, but not buy a 100 obd reader.
Should be a sticky...."Buy obd BMW specific reader, read codes, tell us the codes."

Newy1985 · Post by **Newy1985** » Thu Apr 18, 2024 12:27 am

Hi, first time posting on here and really need some help as after searching hundreds of articles I cannot find the answer to my problem. I have encountered a problem with my e89 roof where the roof extends into its stacked position and the boot lid begins to open as normal but, before the boot lid has risen 6 inches the roof begins to retract clashing with the boot lid.
Any ideas on fix ? I’m lead to believe it could be a hall sensor issue however, I’m puzzled how to access the hall sensors on the boot hinge / ram as I cannot fully open to provide access

Z4-forum.com

Z4-forum.com